Product ID:32-SERIES, ACRYLIC LACQUER SYSTEM, LAC-LF (SUPDAT)
MSDS Date:04/01/1991
FSC:8010
NIIN:00N041652
MSDS Number: BXSPC

MARTIN-SENOUR CO

101 PROSPECT AVE NW
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2283

Cage: 16772

MARTIN-SENOUR CO THE DIV SHERWIN-WILLIAMS CO

CHICAGO, IL 60608-5724 US

Cage: 16772

ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER ACETATE

RTECS: 9999999ZZ

90-118) . METHYL ETHYL KETONE MAY INCR NERVOUS SYS

RTECS: 9999999ZZ

LISTED IN INGREDS MAY CAUSE ADVERSE EFTS TO LIVER,

RTECS: 9999999ZZ

RATS EXPOS TO TITANIUM DIOXIDE DUST AT 250 MG/M3

RTECS: 9999999ZZ

NOT ATTAINABLE IN WORKPLACE. REPORTS HAVE ASSOC

RTECS: 9999999ZZ

SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL

RTECS: 9999999ZZ

FACILITY. DO NOT INCIN CLSD CNTNR. DISPOSE

RTECS: 9999999ZZ

FLAMES, PILOT LIGHTS & HEATERS. TURN OFF

RTECS: 9999999ZZ

OF IGNIT. CONSULT NFPA CODE. USE APPRVD BONDING &

RTECS: 9999999ZZ

DRIED FILM. IF NO SPECIFIC DUSTS ARE LISTED,

RTECS: 9999999ZZ

(TDUST), OSHA PEL 15 MG/M3 (TDUST), 5 MG/M3

RTECS: 9999999ZZ

BY NIOSH/MSHA FOR PROTECTION AGAINST

RTECS: 9999999ZZ

22

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 25-40%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

33

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: <5%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 500 STEL

2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 5-25%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM; 300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA 313)

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: 1-10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 75 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHANOL, 2-BUTOXY-, ACETATE; (2-BUTOXYETHYL ACETATE)

CAS: 112-07-2

RTECS: KJ8925000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

5.2-5.8 LBS/GAL; VOC LESS WATER

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

DANGEROUSLY INCREASED PRESSURES IN CLOSED

RTECS: 9999999ZZ

SHOWN DOSE-RELATED ADVERSE EFTS TO CNS,

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOS MAY BE BY INHAL &/OR SKIN OR EYE
CNTCT DEPENDING ON CNDTNS OF USE. ALCOHOLS & ACETATES CAN BE
ABSORBED THRU SKIN. ACUTE:IRRIT OF EYES, SKIN & RESP SYS. MAY CAUSE
NERVOUS SYS DEPRESS. EXTREME OVE REXP MAY RSLT IN UNCON & POSS
DEATH. HDCH, DIZZ, NAUS & LOSS OF COORDINATION ARE INDICATIONS OF
EXCESS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:EXPOS TO VAPS/SPRAY MISTS. REDNESS &
ITCH/BURNING SENSATION MAY INDICATE EYE/EXCESS SKIN EXPOS. CHRONIC:
TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP H LTH PROFESSIONALS CONCERNING LATEST
HAZLIST INFO & SAFE HNDLG & EXPOS INFO . ANIMAL STUDIES HAVE
CLEARLY (ING 9)
Medical Cond Aggravated by Exposure:NONE KNOWN.

First Aid:INHAL: LEAVE AREA & GET FRESH AIR. IF PROBLEMS REMAIN OR
OCCUR LATER, IMMEDIATELY GET MEDICAL ATTENTION. SKIN: WASH AFFECTED
AREA THOROUGHLY WITH SOAP & WATER. REMOVE CONTAMINATED CLOTHING &
LAUNDER B EFORE RE-USE. EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR
AT LEAST 15 MINUTES. GET MEDICAL ATTENTION. INGEST: GET MEDICAL
ATTENTION.

Flash Point:21.0F,-6.1C
Lower Limits:0.5%
Upper Limits:3.7%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF.
WATER MAY BE USED TO COOL CLSD (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. APPLICATN TO HOT SURFS (SUPDAT)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AND
REMOVE WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTENTS ARE FLAMM. KEEP AWAY FROM
HEAT, SPARK & OPEN FLAME. DURING USE & UNTIL ALL VAPS ARE GONE:
KEEP AREA VENT. DO NOT SMOKE. EXTING ALL (ING 17)
Other Precautions:USE ONLY W/ADEQ VENT. AVOID BRTHG VAP & SPRAY MIST.
AVOID CNTCT W/SKIN & EYES. WASH HANDS AFTER USING. COATING MAY CNTN
MATLS CLASSIFIED AS NUISANCE PARTICULATES WHICH MAY BE PRESENT AT
HAZ LEVELS ONL Y DURING SANDING/ABRADING OF (ING 19)

Respiratory Protection:IF PERSONAL EXPOS CANNOT BE CONTROLLED BELOW
APPLIC LIMS BY VENT WEAR NIOSH/MSHA APPRVD, PROPERLY FITTED ORG
VAP/PARTICULATE RESP. WHEN SANDING, WIREBRUSHING, ABRADING, BURNING
OR WELDING DRIED FILM, WEAR PARTICULATE RESP APPRVD (ING 21)
Ventilation:LOC EXHST PREF. GEN EXHST ACCEPTABLE IF EXPOS IS MAINTAINED
BELOW APPLIC EXPOS LIMS. REFER TO OSHA STDS 1910.94,107,108.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
MFR'S TRADE NAME/PART NO: NON-LEAD COLORS. FIRE FIGHT PROC: CNTNRS TO
PVNT PRESS BUILD-UP & POSS AUTOIGNIT OR EXPLOS WHEN EXPOSED TO
EXTREME HEAT. EXPLO HAZ: REQS SPEC PRECS. DURING EMER CNDTNS OVEREX
P TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE IMMED
APPARENT. OBTAIN MED ATTN.

Boiling Pt:B.P. Text:>132F,>56C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.90-0.99
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:75-85

Stability Indicator/Materials to Avoid:YES
METALLICS CNTN ALUMINUM. CONTAM W/WATER, ACIDS OR ALKALIS CAN CAUSE
EVOLUTION OF HYDROGEN, WHICH MAY RSLT IN (ING 8)
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE. CARBON
MONOXIDE. OXIDES OF METALS LISTED IN INGREDIENTS.

Waste Disposal Methods:WASTE FROM PROD MAY BE HAZ AS DEFINED UNDER RCRA
40CFR 261. WASTE MUST BE TESTED FOR IGNIT TO DETERMINE APPLIC EPA
HAZ WASTE NUMBERS. WASTE FROM PRODS CONTAINING METHYL ETHYL KETONE
MAY REQ TESTING FO R EXTRACTABILITY. INCIN IN APPRVD (ING 16)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.